Volkswagen Golf Owners Manual: Underseal
First read and observe the introductory information
and safety warnings
The underside of the vehicle is coated to protect it from corrosion and damage. The protective coating on the underside of the vehicle could be damaged when driving. Volkswagen therefore recommends that the protective coating on the underside of the vehicle and on the running gear should be checked regularly and repaired if necessary.
CAUTION
- Never apply underseal or anti-corrosion coatings to the exhaust pipes, catalytic converter, heat shields or other vehicle components that become hot.
De-icing the door lock cylinders
First read and observe the introductory information
and safety warnings Volkswagen recommends the use of genuine Volkswagen spray
with lubricating and anti-corrosive properties to de-ice the loc ...
Cleaning the engine compartment
First read and observe the introductory information
and safety warnings The engine compartment of any motor vehicle is a hazardous
area .
The engine compartment should be cleaned by a qual ...
Other materials:
Assembly overview - rear vehicle level senders, multi-link suspension,
four-wheel drive
Note
The vehicle level sender is available as a replacement part only
complete with coupling rod and upper and lower retaining plates.
1 -
Pop rivet nut
2 -
Electrical connector
3 -
Pop rivet ...
Repairs to contacts in contact housings
If necessary, first open or disengage the secondary locking
mechanism of the contact housing
→ Chapter.
–
Disengage the contact (primary locking mechanism) using the
approp ...
Moving mechatronic unit for dual clutch gearbox -J743- into removal position
by hand
Note
Only if you cannot set the mechatronic unit to removal position with
the vehicle diagnostic tester, you must set the unit by hand to removal
position.
Sometimes, the mechatronic unit cannot be removed. In this case, the
gear actuator for 6th gear ...
